驱动装置的作用是驱动混凝土贮罐转动，它由取力器、万向轴、液压泵、液压马达、操纵阀、液压油箱及冷却装置组成。
The driving device is used to drive the concrete storage tank to rotate. It is composed of power take-off, universal shaft, hydraulic pump, hydraulic motor, control valve, hydraulic oil tank and cooling device.
如果这部分因故障停止工作，混凝土贮罐将不能转动，这会导致车内混凝土报废，严重的甚使整罐混凝土凝结在罐内，造成全自动上料搅拌车报废。
If this part stops working due to fault, the concrete storage tank will not be able to rotate, which will lead to the scrapping of the concrete in the vehicle, or even the whole tank of concrete coagulated in the tank, resulting in the scrapping of the automatic feeding mixer.
因此，驱动装置是否可靠是使用中必须高度重视的问题。为保证驱动装置完好可靠，应做好以下维护工作：
Therefore, whether the driving device is reliable or not is a problem that must be attached great importance in use. In order to ensure the integrity and reliability of the driving device, the following maintenance work should be done:
a．万向转动部分是故障多发部位，应按时加注润滑脂，并经常检查磨损情况，及时修理更换。车队应有备用的万向轴总成，以保证一旦发生故障能在几十分钟内恢复工作。
a. Universal rotating part is the fault prone part, should be filled with grease on time, and often check the wear, timely repair and replacement. The team should have a spare cardan shaft assembly to ensure that it can resume work within dozens of minutes in case of failure.
中科聚峰混凝土搅拌车
Zhongke Jufeng concrete mixer
b．保证液压油清洁。全自动上料搅拌车工作环境恶劣，一定要防止污水泥沙进入液压系统。液压油要按使用手册要求定期更换。一旦检查时发现液压油中混入水或泥沙，就要立即停机清洗液压系统、更换液压油。
b. Ensure that the hydraulic oil is clean. The working environment of the full-automatic feeding mixer is bad, so it is necessary to prevent the dirty cement sand from entering the hydraulic system. The hydraulic oil should be changed regularly according to the manual. Once the hydraulic oil is found to be mixed with water or sediment, it is necessary to stop the machine immediately to clean the hydraulic system and replace the hydraulic oil.
c．保证液压油冷却装置有效。要定时清理液压油散热器，避免散热器被水泥堵塞，检查散热器电动风扇运转是否正常，防止液压油温度超标。液压部分只要保证液压油清洁，一般故障不多；但生产厂家不同，使用寿命则不一样。
c. Ensure that the hydraulic oil cooling device is effective. The hydraulic oil radiator should be cleaned regularly to avoid blockage by cement. Check whether the electric fan of the radiator operates normally to prevent the temperature of the hydraulic oil from exceeding the standard. As long as the hydraulic oil is clean, there are not many faults in the hydraulic part, but the service life is different for different manufacturers.
有了全自动上料搅拌车上面的小总结，希望对广大客户有所帮助，如果有什么不理解的或者寻求帮助的请点击我们的网站：/或者来电咨询，我们会尽全力为您
With the summary of the full-automatic feeding mixer, we hope to help our customers. If you don't understand or ask for help, please click our website: / Or call consultation, we will try our best to solve for you
山汽微信
2022-12-23
首页
产品
电话
置顶